Duct Sealing (Aerosol) in Arlington, TX
Leaky ducts dump conditioned air into attics and wall cavities, and in most homes the worst leaks sit where nobody can reach them. Aerosol sealing works from the inside out: we mask the registers, pressurize the duct system, and release an atomized sealant that the escaping air carries to every gap, where it builds across the opening until it closes. The equipment measures duct leakage before and after, so you get a number on paper rather than a claim. We start with the test — if your system is already tight, we tell you and you pay for the test alone. Starting price covers a typical single-system home; it moves with system size, a second or third system, and how much accessible damage has to be repaired first, since sealant closes gaps but not a disconnected run. Serving Arlington (17 ZIP codes, 399k residents) and surrounding neighborhoods with same-week scheduling.
Duct Sealing (Aerosol) in Arlington
Leaky ducts dump conditioned air into attics and wall cavities, and in most homes the worst leaks sit where nobody can reach them. Aerosol sealing works from the inside out: we mask the registers, pressurize the duct system, and release an atomized sealant that the escaping air carries to every gap, where it builds across the opening until it closes. The equipment measures duct leakage before and after, so you get a number on paper rather than a claim. We start with the test — if your system is already tight, we tell you and you pay for the test alone. Starting price covers a typical single-system home; it moves with system size, a second or third system, and how much accessible damage has to be repaired first, since sealant closes gaps but not a disconnected run.
Local dossier · Arlington, TX
Arlington filled in through the 1980s and 90s and has added very little new housing since, which makes it one of the most consistent duct-age markets in Tarrant County. The typical system here is a quarter century to forty years old: flex duct run through a vented attic, insulation compressed at every strap and bend, sometimes sagging low enough to hold settled debris in the belly of a run. Electric heat dominates, so most homes have an air handler and a heat pump rather than a gas furnace, and that changes what is worth inspecting. Heat pumps run long, low-temperature cycles, and the indoor coil is where moisture actually condenses. When there is a biological problem in an Arlington house, it usually starts at that coil and in the first few feet of supply plenum, not deep in the branch runs. Cleaning branches while ignoring the coil is money spent on the wrong end of the system.
AT&T Stadium
Duct Sealing (Aerosol) in Arlington (Tarrant County) — what's local
Arlington sits in Tarrant County (county seat: Fort Worth). For duct sealing (aerosol) that means our Arlington crew sizes up the local housing stock before quoting — and follows Tarrant County permit requirements for any work that needs an inspection sign-off.
Scoped from a camera inspection
At Prime Air Duct Experts, a duct sealing (aerosol) is never guesswork. We scope every job from a camera look inside the ducts first — weighed against EPA guidance on when the work is actually warranted — so what you approve is matched to what your system actually needs, with the photos to prove it. And if the camera says the work isn't needed, we tell you that instead.
Camera duct inspection in ArlingtonEvery duct sealing (aerosol) in Arlington
Deliverables
- Pre-seal duct leakage test with the measured result recorded
- Registers masked and the full system pressurized for aerosol sealing
- Post-seal test on the same equipment — before-and-after numbers in writing
- Accessible tears and disconnections repaired first, because sealant cannot bridge an open run
- Written report you can hand to an inspector or a utility rebate program
How a job runs
Arrive
1-hour arrival window, text 30 min before with tech's name + photo.
Inspect
Full inspection with photos so you see what we see.
Execute
ACR-standard source removal, HEPA collection, clean site.
Document
Photo report + 1-year workmanship warranty in writing.
7+ neighborhoods in Arlington
Same-week service across every neighborhood in Arlington. Don't see yours? Call (469) 287-0686 — if it's in Arlington, we cover it.
The Arlington advantage.
Our Arlington crew lives in the metro they serve, across Tarrant County. They know which Arlington neighborhoods — Pantego, Dalworthington Gardens, Viridian and more — collect the most dust, and which newer builds still have construction debris in the runs. Local knowledge, local referrals, local accountability for every duct sealing (aerosol).
More services in Arlington
Prices shown are starting estimates and may change with the condition, access, and scope we find on site. Only a written quote from an on-site visit is a price we commit to.
Duct Sealing (Aerosol) in nearby Tarrant cities
We cover duct sealing (aerosol) across Tarrant County — same crew, same warranty. Nearby Arlington cities we also serve:
Last reviewed:
Get it inspected. Get it in writing.
Flat fee confirmed when you book. Same-week scheduling. A pass/fail verdict within 48 hours.
24/7 Response
Water intrusion in the ducts, a musty smell that won't quit, or vermin in the system? We answer 7 AM to midnight and every visit ends with camera photos and a written verdict — including a straight "your ducts are fine" when that's what we find. After-hours dispatch runs subject to crew availability.
Emergency line