Duct Sealing (Aerosol) in Boerne, TX
Leaky ducts dump conditioned air into attics and wall cavities, and in most homes the worst leaks sit where nobody can reach them. Aerosol sealing works from the inside out: we mask the registers, pressurize the duct system, and release an atomized sealant that the escaping air carries to every gap, where it builds across the opening until it closes. The equipment measures duct leakage before and after, so you get a number on paper rather than a claim. We start with the test — if your system is already tight, we tell you and you pay for the test alone. Starting price covers a typical single-system home; it moves with system size, a second or third system, and how much accessible damage has to be repaired first, since sealant closes gaps but not a disconnected run. Serving Boerne (3 ZIP codes, 20k residents) and surrounding neighborhoods with same-week scheduling.
Duct Sealing (Aerosol) in Boerne
Leaky ducts dump conditioned air into attics and wall cavities, and in most homes the worst leaks sit where nobody can reach them. Aerosol sealing works from the inside out: we mask the registers, pressurize the duct system, and release an atomized sealant that the escaping air carries to every gap, where it builds across the opening until it closes. The equipment measures duct leakage before and after, so you get a number on paper rather than a claim. We start with the test — if your system is already tight, we tell you and you pay for the test alone. Starting price covers a typical single-system home; it moves with system size, a second or third system, and how much accessible damage has to be repaired first, since sealant closes gaps but not a disconnected run.
Local dossier · Boerne, TX
Nearly everything in Boerne is new by Texas standards. The town's housing is dominated by subdivisions raised over the past twenty-five years, with a very large share finished since 2010, so duct systems here are rarely dirty from decades of use. They are dirty, when they are, because of how they were built. Hill Country lots get cut into limestone and caliche, and that dust is fine, abrasive and everywhere on a jobsite. It settles into open boots during framing, then mixes with drywall sanding residue before the registers ever go on. The second Boerne fact worth planning around is heat. Almost nobody here burns gas; homes run heat pumps and strip heat, so there is no flue or heat exchanger in the picture and the indoor coil becomes the thing worth opening. And Kendall County sits inside dense Ashe juniper, which makes filtration, rather than scrubbing, the honest winter answer for most households.
the Cibolo Center for Conservation
Duct Sealing (Aerosol) in Boerne (Kendall County) — what's local
Boerne sits in Kendall County (county seat: Boerne). For duct sealing (aerosol) that means our Boerne crew sizes up the local housing stock before quoting — and follows Kendall County permit requirements for any work that needs an inspection sign-off.
Scoped from a camera inspection
At Prime Air Duct Experts, a duct sealing (aerosol) is never guesswork. We scope every job from a camera look inside the ducts first — weighed against EPA guidance on when the work is actually warranted — so what you approve is matched to what your system actually needs, with the photos to prove it. And if the camera says the work isn't needed, we tell you that instead.
Camera duct inspection in BoerneEvery duct sealing (aerosol) in Boerne
Deliverables
- Pre-seal duct leakage test with the measured result recorded
- Registers masked and the full system pressurized for aerosol sealing
- Post-seal test on the same equipment — before-and-after numbers in writing
- Accessible tears and disconnections repaired first, because sealant cannot bridge an open run
- Written report you can hand to an inspector or a utility rebate program
How a job runs
Arrive
1-hour arrival window, text 30 min before with tech's name + photo.
Inspect
Full inspection with photos so you see what we see.
Execute
ACR-standard source removal, HEPA collection, clean site.
Document
Photo report + 1-year workmanship warranty in writing.
4+ neighborhoods in Boerne
Same-week service across every neighborhood in Boerne. Don't see yours? Call (469) 287-0686 — if it's in Boerne, we cover it.
The Boerne advantage.
Our Boerne crew lives in the metro they serve, across Kendall County. They know which Boerne neighborhoods — Hill Country Village, Esperanza, Cordillera Ranch and more — collect the most dust, and which newer builds still have construction debris in the runs. Local knowledge, local referrals, local accountability for every duct sealing (aerosol).
More services in Boerne
Prices shown are starting estimates and may change with the condition, access, and scope we find on site. Only a written quote from an on-site visit is a price we commit to.
Duct Sealing (Aerosol) in nearby Kendall cities
We cover duct sealing (aerosol) across Kendall County — same crew, same warranty. Nearby Boerne cities we also serve:
Last reviewed:
Get it inspected. Get it in writing.
Flat fee confirmed when you book. Same-week scheduling. A pass/fail verdict within 48 hours.
24/7 Response
Water intrusion in the ducts, a musty smell that won't quit, or vermin in the system? We answer 7 AM to midnight and every visit ends with camera photos and a written verdict — including a straight "your ducts are fine" when that's what we find. After-hours dispatch runs subject to crew availability.
Emergency line