New-Construction Duct Dust-Out in Boerne, TX
New homes routinely come with pre-loaded ductwork: drywall sanding dust, sawdust, insulation fragments, tape scraps — swept into open registers over months of construction and waiting for your first cooling season to circulate. A dust-out is a full source-removal cleaning tuned to construction debris, done ideally after final sanding and before move-in. We put the system under negative pressure, agitate every run, clear both plenums, and camera-verify the result, so your brand-new system starts life actually clean. We coordinate directly with builders and GCs on scheduling, and the report we leave works as closing documentation. Serving Boerne (3 ZIP codes, 20k residents) and surrounding neighborhoods with same-week scheduling.
New-Construction Duct Dust-Out in Boerne
During construction, duct systems sit open through the dustiest work a house will ever see. Drywall sanding, tile cutting, insulation, and sweeping all happen with registers uncovered and, often, the system running without proper filters — so brand-new ductwork routinely holds a layer of fine mineral dust, sawdust, and jobsite debris. A dust-out is a full source-removal cleaning tuned to that debris: negative pressure, agitation through every run, both plenums cleared, and a camera pass to verify. Timed after final sanding and before move-in, it means your new system's first cooling season circulates clean air instead of the jobsite.
Local dossier · Boerne, TX
Nearly everything in Boerne is new by Texas standards. The town's housing is dominated by subdivisions raised over the past twenty-five years, with a very large share finished since 2010, so duct systems here are rarely dirty from decades of use. They are dirty, when they are, because of how they were built. Hill Country lots get cut into limestone and caliche, and that dust is fine, abrasive and everywhere on a jobsite. It settles into open boots during framing, then mixes with drywall sanding residue before the registers ever go on. The second Boerne fact worth planning around is heat. Almost nobody here burns gas; homes run heat pumps and strip heat, so there is no flue or heat exchanger in the picture and the indoor coil becomes the thing worth opening. And Kendall County sits inside dense Ashe juniper, which makes filtration, rather than scrubbing, the honest winter answer for most households.
the Cibolo Center for Conservation
Common signs in Boerne homes
- A white, gritty film that keeps returning to fresh surfaces
- Visible drywall dust or debris sitting in register boots
- A dusty or sawdust smell when the system first runs
- The builder can't document that ducts were cleaned after construction
- Filters clogging fast in a home that's only months old
New-Construction Duct Dust-Out in Boerne (Kendall County) — what's local
Boerne sits in Kendall County (county seat: Boerne). For new-construction duct dust-out that means our Boerne crew sizes up the local housing stock before quoting — and follows Kendall County permit requirements for any work that needs an inspection sign-off.
Built to standard · New-Construction Duct Dust-Out in Boerne
New-Construction Duct Dust-Out is measured against published industry standards no matter the city. Our Boerne crew does every job to these and documents the work — the same method and before-and-after photos, whether it's a single register or a whole-home system.
- NADCA ACR — New construction is one of the clearest cases the ACR approach anticipates: assess the debris, remove it at the source under negative pressure, and verify the system is clean before occupancy.
- EPA guidance — Significant debris in ductwork is one of EPA's stated conditions for cleaning — and construction leftovers are exactly that. Our pre-clean photos document the condition before we touch anything.
Scoped from a camera inspection
At Prime Air Duct Experts, a new-construction duct dust-out is never guesswork. We scope every job from a camera look inside the ducts first — weighed against EPA guidance on when the work is actually warranted — so what you approve is matched to what your system actually needs, with the photos to prove it. And if the camera says the work isn't needed, we tell you that instead.
Camera duct inspection in BoerneEvery new-construction duct dust-out in Boerne
Deliverables
- Full-system source removal tuned to drywall and construction fines
- Both plenums cleared and a fresh filter installed
- Camera verification photos of the finished runs
- Builder- and closing-ready completion report
How a job runs
Pre-clean camera pass
We photograph the construction debris in place first, so the before-and-after comparison is real evidence, not marketing.
Seal and pressurize
Registers sealed, vacuum connected at the trunk, and the full system placed under negative pressure with HEPA collection.
Agitate every run
Drywall fines cling harder than household dust — each run gets mechanical agitation end to end until the camera says done.
Plenums and filter
Both plenums cleared by hand, register boots vacuumed, and a fresh filter installed for the first real cooling season.
Verify and report
A final camera pass, after photos, and a completion report formatted for closings and builder documentation.
4+ neighborhoods in Boerne
Same-week service across every neighborhood in Boerne. Don't see yours? Call (469) 287-0686 — if it's in Boerne, we cover it.
The Boerne advantage.
Our Boerne crew lives in the metro they serve, across Kendall County. They know which Boerne neighborhoods — Hill Country Village, Esperanza, Cordillera Ranch and more — collect the most dust, and which newer builds still have construction debris in the runs. Local knowledge, local referrals, local accountability for every new-construction duct dust-out.
More services in Boerne
Prices shown are starting estimates and may change with the condition, access, and scope we find on site. Only a written quote from an on-site visit is a price we commit to.
New-Construction Duct Dust-Out in nearby Kendall cities
We cover new-construction duct dust-out across Kendall County — same crew, same warranty. Nearby Boerne cities we also serve:
New-Construction Duct Dust-Out in Boerne — FAQ
Shouldn't my builder have cleaned the ducts already?
Sometimes it's in the contract; often it's skipped or done superficially in the rush to closing. Ask your builder for documentation — an invoice and photos. If they can't produce it, our camera answers the question in an hour, and the pre-clean photos give you standing to raise it before your warranty window closes.
When is the ideal time to schedule a dust-out?
After the final sanding and paint work, before move-in — that's when the ducts have collected everything they're going to collect and your belongings aren't in the way. Already moved in? Still absolutely worth doing; the work is identical, we just add drop cloths and a little more care around furniture.
We just built in a Boerne subdivision. Should the ducts be cleaned before we move in?
Worth an inspection, certainly. Hill Country builds cut through limestone and caliche, and that dust is fine and abrasive. Boots left open during framing collect it alongside drywall sanding residue. If your builder capped the openings and the system looks clean, we will say so and charge you for nothing further.
Almost every house here runs electric heat. What does that change about duct work?
It removes combustion from the equation, so there is no flue or heat exchanger to inspect. The questions become moisture and dust instead. Heat pumps and strip heat move air across an indoor coil that condenses water, and that coil plus the first stretch of supply plenum is where Kendall County problems tend to start.
Cedar season is severe out here. Will cleaning the ducts help?
Only with what has already settled. Kendall County sits in thick Ashe juniper and counts here run higher than in town, but ducts recirculate what is already indoors rather than generating it. Sealing the return side and matching a good filter to your blower does the real work through January and February.
Do you serve all of Boerne?
Yes — our crews cover Boerne's 3 ZIP codes across Kendall County, including Hill Country Village, Esperanza, Cordillera Ranch, plus the surrounding communities.
How soon can you schedule new-construction duct dust-out in Boerne?
We offer same-week scheduling across Boerne, booked by a real person in under two minutes, 7 AM to midnight every day.
How much does new-construction duct dust-out cost in Boerne, TX?
New-Construction Duct Dust-Out in Boerne starts from $450, but the honest number depends on what a craftsman finds on site — we won't quote premium work blind. Our technician inspects the actual condition on camera, then hands you an itemized, transparent written quote tied to the findings and built to the NADCA ACR standard. No teaser pricing, no surprises. Call (469) 287-0686 for a free, no-pressure Boerne quote.
Do you offer emergency or same-day new-construction duct dust-out in Boerne?
Yes — we run same-week and emergency new-construction duct dust-out across Boerne, scheduled by a real person 7 AM to midnight every day. For an urgent air-quality concern, call (469) 287-0686 and we prioritize Boerne dispatch so a technician is on it fast.
Is there a professional new-construction duct dust-out company near me in Boerne?
Our Boerne crew lives in and works the metro across Kendall County, including Hill Country Village, Esperanza, Cordillera Ranch — a certified, local new-construction duct dust-out team genuinely near you, holding the same national craftsmanship standard on every job, not dispatched cold from another city. Call (469) 287-0686.
Last reviewed:
Get it inspected. Get it in writing.
Flat fee confirmed when you book. Same-week scheduling. A pass/fail verdict within 48 hours.
24/7 Response
Water intrusion in the ducts, a musty smell that won't quit, or vermin in the system? We answer 7 AM to midnight and every visit ends with camera photos and a written verdict — including a straight "your ducts are fine" when that's what we find. After-hours dispatch runs subject to crew availability.
Emergency line