Duct Sealing (Aerosol) in Schertz, TX
Leaky ducts dump conditioned air into attics and wall cavities, and in most homes the worst leaks sit where nobody can reach them. Aerosol sealing works from the inside out: we mask the registers, pressurize the duct system, and release an atomized sealant that the escaping air carries to every gap, where it builds across the opening until it closes. The equipment measures duct leakage before and after, so you get a number on paper rather than a claim. We start with the test — if your system is already tight, we tell you and you pay for the test alone. Starting price covers a typical single-system home; it moves with system size, a second or third system, and how much accessible damage has to be repaired first, since sealant closes gaps but not a disconnected run. Serving Schertz (3 ZIP codes, 42k residents) and surrounding neighborhoods with same-week scheduling.
Duct Sealing (Aerosol) in Schertz
Leaky ducts dump conditioned air into attics and wall cavities, and in most homes the worst leaks sit where nobody can reach them. Aerosol sealing works from the inside out: we mask the registers, pressurize the duct system, and release an atomized sealant that the escaping air carries to every gap, where it builds across the opening until it closes. The equipment measures duct leakage before and after, so you get a number on paper rather than a claim. We start with the test — if your system is already tight, we tell you and you pay for the test alone. Starting price covers a typical single-system home; it moves with system size, a second or third system, and how much accessible damage has to be repaired first, since sealant closes gaps but not a disconnected run.
Local dossier · Schertz, TX
Schertz is unusual in two ways that matter for ductwork. Almost every home is detached single-family, with very little attached or stacked housing anywhere in the city, and almost every one of them heats with electricity rather than gas. That means no flue, no heat exchanger, and one cabinet doing all the work: blower, evaporator coil, filter rack and strip heaters in a single box that is where nearly every real air-quality issue in this city begins. It also explains the burning smell people report on the first cold morning, which is dust scorching on the heat strips rather than a failure. The other local factor is turnover. With Randolph and the wider joint base next door, houses here change hands and tenants often, and a system inherits whatever the last household did to it. We find that history in the cabinet before quoting anything.
Crescent Bend Nature Park
Duct Sealing (Aerosol) in Schertz (Guadalupe County) — what's local
Schertz sits in Guadalupe County (county seat: Seguin). For duct sealing (aerosol) that means our Schertz crew sizes up the local housing stock before quoting — and follows Guadalupe County permit requirements for any work that needs an inspection sign-off.
Scoped from a camera inspection
At Prime Air Duct Experts, a duct sealing (aerosol) is never guesswork. We scope every job from a camera look inside the ducts first — weighed against EPA guidance on when the work is actually warranted — so what you approve is matched to what your system actually needs, with the photos to prove it. And if the camera says the work isn't needed, we tell you that instead.
Camera duct inspection in SchertzEvery duct sealing (aerosol) in Schertz
Deliverables
- Pre-seal duct leakage test with the measured result recorded
- Registers masked and the full system pressurized for aerosol sealing
- Post-seal test on the same equipment — before-and-after numbers in writing
- Accessible tears and disconnections repaired first, because sealant cannot bridge an open run
- Written report you can hand to an inspector or a utility rebate program
How a job runs
Arrive
1-hour arrival window, text 30 min before with tech's name + photo.
Inspect
Full inspection with photos so you see what we see.
Execute
ACR-standard source removal, HEPA collection, clean site.
Document
Photo report + 1-year workmanship warranty in writing.
4+ neighborhoods in Schertz
Same-week service across every neighborhood in Schertz. Don't see yours? Call (469) 287-0686 — if it's in Schertz, we cover it.
The Schertz advantage.
Our Schertz crew lives in the metro they serve, across Guadalupe County. They know which Schertz neighborhoods — The Crossvine, Greenshire, Carolina Crossing and more — collect the most dust, and which newer builds still have construction debris in the runs. Local knowledge, local referrals, local accountability for every duct sealing (aerosol).
More services in Schertz
Prices shown are starting estimates and may change with the condition, access, and scope we find on site. Only a written quote from an on-site visit is a price we commit to.
Duct Sealing (Aerosol) in nearby Guadalupe cities
We cover duct sealing (aerosol) across Guadalupe County — same crew, same warranty. Nearby Schertz cities we also serve:
Last reviewed:
Get it inspected. Get it in writing.
Flat fee confirmed when you book. Same-week scheduling. A pass/fail verdict within 48 hours.
24/7 Response
Water intrusion in the ducts, a musty smell that won't quit, or vermin in the system? We answer 7 AM to midnight and every visit ends with camera photos and a written verdict — including a straight "your ducts are fine" when that's what we find. After-hours dispatch runs subject to crew availability.
Emergency line