Duct Sealing (Mastic, Accessible Runs) in Hurst
Hand-sealed joints wherever a technician can physically reach the ductwork.
01Hurst — the housing record
What Hurst actually has behind its walls.
Before anyone quotes a duct job here, this is the stock they are quoting against. It is public Census data, and it is different in every city we cover.
- Housing units
- 16,530
- Built pre-1980
- 41%
- Built 2000s
- 17%
- Built since 2010
- 3%
- Gas heat
- 39%
- Electric heat
- 60%
- Single-family
- 63%
U.S. Census Bureau, American Community Survey 5-Year Estimates (2023), tables B25034, B25040 and B25024. Percentages are rounded and describe the city, not your house.
What that means for ducts
Retrofit-era ductwork
About 41% of Hurst's homes went up before 1980, which is before central air was designed into a house rather than added to it. Duct runs in that stock were threaded through attics and crawl spaces after the fact, often more than once, and the flex in them has had decades of Texas attic heat. Expect route surprises, expect joints that have worked loose, and expect a system nobody has opened.
That is a reading of the city’s stock, not a diagnosis of your home. Which of it applies to you is exactly what the camera settles — and why we would rather run one than quote from a postcode.
02Working in Hurst
The part that changes from street to street.
Hurst holds the oldest housing of anywhere we work in the Mid-Cities, and almost nothing has been added in the past fifteen years, so what we open here is generally a 1960s or 70s ranch that has had its equipment replaced two or three times over. Each replacement was faster and cheaper than a duct renovation, so the new unit got bolted to the old plenum. We regularly find a modern air handler pushing into a transition built for a machine nobody has manufactured in forty years. That mismatch shows up as noise, as static pressure the blower was never rated for, and as dirt driven into the coil face rather than caught by the filter. The other Hurst particular is what the original ductwork is wrapped in. Insulation and tape on pre-1980 systems can contain asbestos, and it is not something you brush to find out. When the material looks the part we stop, tell you, and recommend testing before any tool goes through it. That is a slower and less profitable visit and it is the correct one.
the Hurst Conference Center
Same standard in Hurst as everywhere else.
Source removal to the NADCA ACR standard, a written quote before anything is touched, and camera photographs of your own runs before and after. We are not going to re-argue that on every city page — it is set out once, in full, on the service page.
- Leak locations found and photographed before anything is sealed
- Every reachable joint, takeoff, and boot hand-sealed with mastic
- Fabric mesh embedded over the wider gaps so the seal does not crack open
- Failed foil tape stripped off rather than sealed over
- Written note of any leak we could not reach, and what closing it would take
- From
- $695
- On site
- 3–5 hours
- Scope
- 5 lines
Prices shown are starting estimates and may change with the condition, access, and scope we find on site. Only a written quote from an on-site visit is a price we commit to.
03Duct Sealing (Mastic, Accessible Runs) — in this stock
Leakage in retrofitted runs.
Duct leakage is worst where the ductwork was added later, and in stock this age it is common to find a system losing a meaningful share of its conditioned air into an attic. That shows up on a summer bill long before anyone thinks about ducts. Sealing here is often the higher-value purchase than cleaning — and unlike a cleaning, it has a before-and-after number attached to it.
Ask us anything about this on the phone — a person answers during opening hours.
All duct sealing (mastic, accessible runs) questions04Book in Hurst
Three fields, and a person calls you back.
Tell us the ZIP and we will tell you what your system likely needs — including, sometimes, that it needs nothing yet. Nothing is charged until you have approved a written quote.
05Questions
Asked in Hurst, answered straight.
Our ranch house is from 1968 and we just replaced the AC. Should the ducts have been done then?
The plenum and the transition should at least have been looked at, and frequently they are not. A new unit tied into an old plenum can move less air than the one it replaced. We put gauges across the system and show you the number, because that tells you whether you are looking at a cleaning problem, a fitting problem, or a system that is genuinely fine.
How would we know if there is asbestos in the duct insulation?
Not by looking, and we would not claim certainty either. Material of that era, particularly the wrap on trunk lines and the tape at the joints, sometimes contains it. If your system looks like a candidate we stop and recommend a lab test rather than proceeding, because disturbing it is the one action that turns it into a real problem. The test is inexpensive next to the alternative.
A bedroom was added when the garage was converted and it never keeps up.
Those rooms are usually the weakest performer in a Hurst house. The conversion typically pulled a branch off the nearest trunk without adding any return path, so conditioned air arrives with nowhere to go and the room sits warm no matter how clean the duct is. Giving that room a way back to the return fixes what cleaning cannot.
Duct Sealing (Mastic, Accessible Runs) nearby
- Fort Worth ·
- Arlington ·
- Grand Prairie ·
- Grapevine ·
- Southlake ·
- Colleyville ·
- Keller ·
- Trophy Club ·
- Westlake ·
- Haslet
Last reviewed: